Create Designer Digs for Your Dog Using an Upcycled Pallet

Here's an easy-to-build doghouse that's not only adorable (check out that rooftop garden!), but it puts a wooden pallet to good use.

DIY Doghouse

DIY Doghouse

Humans aren’t the only ones who enjoy an attractive, cozy place to kick back and relax. Pets deserve amazing digs, too. Here’s an easy to build dog house that’s not only adorable with a rooftop garden, it puts an old wooden pallet and other leftover materials to good use. Upcycling has never been this cute!

Photo by: Flynnside Out Productions

Flynnside Out Productions

Materials

  • (1) pressure-treated 2x4
  • (1) pressure-treated 1x4
  • (1) pressure-treated 1x2
  • (1) wood pallet
  • scrap sheet metal or PT plywood
  • deck screws
  • wood stain
  • exterior-grade silicone sealant
  • paintbrush
  • old rags
  • drop cloth
  • roofing materials
  • plants + soil

Tools

  • measuring tape
  • pencil
  • eye protection
  • compound or circular saw
  • jig saw or reciprocating saw
  • drill
  • clamps
  • compressor and nail gun

STEP 1: Repurpose a Wooden Pallet

Building a custom doghouse can be a snap when you create the base from an old wooden pallet. Using a reciprocating saw or a jig saw, cut the pallet in half (approximately 24"x26"), leaving the vertical braces intact (Image 1A). Flip the pallet upside down, then secure the pressure-treated 2x4s to the inside rails using galvanized nails or deck screws (Image 1B). Don't skip this step; any wood that's in contact with the ground should always be pressure-treated. Flip the pallet right side up, then add 1x4s across the top to give the doghouse a chic "hardwood floor."

STEP 2: Frame It Out

Next, fasten vertical corner boards to the pallet using deck screws (Image 2A). (We alternated using leftover 1x4s from building the fence and 1x2s to achieve a vertical groove siding look.) If you're using screws rather than nails, you may want to drill pilot holes to avoid splitting your wood. Use 2x4s to frame out the top horizontally (at a slight angle if you like the sloped roof look). Then, fasten a 2x4 brace across the middle to reinforce the roof (Image 2B).

STEP 3: Install Siding

With the framing in place, continue building out the sides. Alternate 1x2s by fastening to the upper and lower horizontal boards with 1x4s. Always use whole boards on the corners, so you can rip the middle boards to size. Trim vertical boards to follow the line of the upper horizontal 2x4s you installed in the previous step. Use a circular saw or reciprocating saw to do this, and if it helps, you can always pop a chalk line as a guide.

IMAGE 3

Photo by: Flynnside Out Productions

Flynnside Out Productions

IMAGE 3

STEP 4: Raise the Roof

Measure across the top of the doghouse, then mark and cut your roofing material to size. This is another opportunity to upcycle leftover materials. We cut some scrap sheet metal to size using a jig saw, then secured it to the top of the doghouse with screws. With your "roof deck" in place, you can add shingles (be sure to install felt paper or some type of weather shield underneath). To create a shallow rooftop garden, we added an extra-tall lip along the edge using additional trim. Be sure to seal any seams with an exterior-grade silicone to prevent rainwater from seeping into the interior.

IMAGE 4

Photo by: Flynnside Out Productions

Flynnside Out Productions

IMAGE 4

STEP 5: Stain It

Protect your new dog digs with a stain/sealant combo. Whether you rag, brush or spray it on, you'll be glad you did. The stain will protect the wood from moisture and UV rays that can eventually cause wood to warp, crack, mildew or rot. TIP: You won't need much, so utilize some leftover from a previous project.

IMAGE 5

Photo by: Flynnside Out Productions

Flynnside Out Productions

IMAGE 5

STEP 6: Extra, Extra

Once the doghouse is stained and dry to the touch, move it into place. It's best to install it near a garden hose for easy cleanups to the exterior and a periodic spray out of the interior. And don't forget to utilize the roof of the doghouse in some way, whether it's a shallow planter for colorful blooms or a cute storage container to house toys and bowls.

IMAGE 6

Photo by: Flynnside Out Productions

Flynnside Out Productions

IMAGE 6

STEP 7: Finishing Touches

Finally, add a dog bed, fun outdoor-only toys and a water bowl to create a welcoming environment your pet is sure to love.

Shelter in Style

Shelter in Style

Providing some type of shelter is also a key design feature. A dog house gives your pet a “den” and plays to their natural instincts to stay cool and comfortable. Bonus points for making one that looks a bit like your own home! See how to build one from upcycled materials HERE (link to our SXS?)

Photo by: Flynnside Out Productions

Flynnside Out Productions

Keep Reading

Next Up

19 Drool-Worthy Spaces Just for Your Dog + 5 Dog Treat Recipes

It’s National Dog Day! Don’t miss an opportunity to pamper your pup.

How to Make a Cat Condo

Use everyday items to build a fancy cat jungle gym.

Turn a Step Stool Into a Sensory Playground for Cats

Create the ultimate sensory playground for felines with brushes, fringe, jute and more.

How to Install an Electric Underground Fence for Pets

Save on installation costs by learning how to run your own "invisible" home fence for the containment and safety of your furry BFF.

How to Make an Upcycled Kitty Playground

Give kitty a fun place to play and rest by upcycling thrift store dressers.

Perfectly Portable Pup Tent for Easy Summer Shade

From picnics in the park to barbecues in the backyard, there’s one thing that is a doggy essential: a sun-shielding, dog-sized tent.

Kitty Cat Glamping Made Easy: DIY Fur-stream

Learn how to make the purrfect home away from home for your furry friend.

T-Shirt Turned Cozy Cat Hideout

Glamping with your kitty has never been so easy. Your feline friend will absolutely love this tiny t-shirt tent.

Dog Walker's Companion

This DIY walker companion is ideal for picking up after your pooch when they have to go while on-the-go.

Follow Us Everywhere

Join the party! Don't miss HGTV in your favorite social media feeds.